https://www.engineeringnews.co.za
Concrete|Construction|Design|Environment|Financial|Flow|PROJECT|Projects|Road|Roads|Flow|Maintenance
Concrete|Construction|Design|Environment|Financial|Flow|PROJECT|Projects|Road|Roads|Flow|Maintenance
concrete|construction|design|environment|financial|flow-company|project|projects|road|roads|flow-industry-term|maintenance

Covid-19 will not affect current capex, but future projects dependent on recovery, says Trac

20th November 2020

By: Irma Venter

Creamer Media Senior Deputy Editor

     

Font size: - +

The Covid-19 pandemic will not affect the roll-out of the current R1.6-billion worth of capital projects along the N4, says Trans African Concessions (Trac) CEO Alex van Niekerk.

Trac manages the N4 toll route between Tshwane, in Gauteng, and the Maputo port, in Mozambique.

“When the country went to Alert Level 4 from Level 5, we restarted all of our construction projects. In view of this, there was a delay in capital spend, but we are pleased to announce that no project has been stopped,” says Van Niekerk.

Trac has four large capital projects being rolled out currently, aside from the routine maintenance projects continuously carried out on the N4.

The first project is between eMalahleni and Middelburg, where the old concrete section of the freeway is being rehabilitated and passing lanes being constructed at steep gradients.

Another project is between Belfast and Machadodorp, with this section being upgraded to a four-lane undivided road, with an interchange at Machadodorp.

The third project is the development of the Karino interchange, east of Mbombela.

“The Karino interchange upgrade will see the existing at-grade intersection transformed into a grade-separated interchange with on- and off-ramps and a bridge over the N4. This is a complex project mostly due to the challenging topography and large volumes of hard rock in the area,” says Van Niekerk.

The last project is the upgrade between Kaapmuiden and Malalane, which will see this section widened to a four-lane undivided road.

Van Niekerk says it was unavoidable that Covid-19 would impact on Trac’s revenue.

“Although we are on the recovery path, it should be noted that we are still recording 20% less traffic volumes, in comparison to last year. We dropped to only 15% of normal traffic volumes in April.

“For the previous financial year, which ended July 31 – four months of Covid-19 – we experienced an annual revenue decline of approximately 10%.”

Van Niekerk expects Covid-19 to have an impact on Trac’s future capital projects, although the extent of the impact is unclear.

“The reduction in traffic volumes, and associated revenue and cash flow, will create challenges with regard to the future need to implement some of the previously envisaged expansion projects.

“In this regard, we distinguish between maintenance of the road and the construction of additional lanes. In terms of the concession contract, the N4 will always be properly maintained. Expansions are triggered in terms of traffic volumes and, due to the reduction in traffic, some expansion projects may not be triggered.”

Projects still on the horizon for Trac are extensive upgrades to the road through Schoemanskloof, where the N4 splits, at the section between Machadodorp and Montrose.

“In this particular area, there are only two lanes with narrow shoulders, and we are looking at constructing extensive climbing lanes,” says Van Niekerk.

“The design work for this project is at an advanced stage and we are keen to get it going next year.”

Trac is also planning the construction of a directional interchange at the point where the ‘two’ N4s connect at the Crocodile river, before Montrose.

This will be quite a substantial project, with two bridges over the N4 and another over the Crocodile river.

“In these uncertain times, these two projects are the most likely to be implemented in the near future”, says Van Niekerk. “Other projects are dependent on traffic volumes.”

Van Niekerk says it is guesswork as to when and if traffic volumes will normalise.

“We hope to recover to 95% to 96% of normal traffic by the end of this financial year. We will be pleased if this materialises, although we don’t expect that the traffic and associated revenue will fully recover before the end of the concession period.”

Trac has more than seven years remaining on its 30-year concession.

Van Niekerk says he views the concession as a successful venture for the private sector and government alike, as the project saw a 214% increase in total traffic on the South African side from 2001 to November 2019. Class-4 heavy-vehicle traffic increased by more than 420%.

In Mozambique, Class-4 heavy-vehicle traffic increased by 1743%, as the road opened up access to the Maputo port.

Total traffic in Mozambique increased by 240%.

From Sanral to Trac
Van Niekerk was appointed as Trac CEO in March, just before the pandemic hit.

He moved from the South African National Roads Agency Limited (Sanral), where he was a familiar face in the Gauteng toll environment.

“It was an opportunity that presented itself after 25 years at Sanral, and I considered that it was time for a new challenge.”

Edited by Martin Zhuwakinyu
Creamer Media Senior Deputy Editor

Comments

Showroom

Rio-Carb
Rio-Carb

Our Easy Access Chute concept was developed to reduce the risks related to liner maintenance. Currently, replacing wear liners require that...

VISIT SHOWROOM 
M and J Mining
M and J Mining

M and J Mining are leading suppliers of physical support systems as used by the underground mining industry. Our selection of products are not...

VISIT SHOWROOM 

Latest Multimedia

sponsored by

Option 1 (equivalent of R125 a month):

Receive a weekly copy of Creamer Media's Engineering News & Mining Weekly magazine
(print copy for those in South Africa and e-magazine for those outside of South Africa)
Receive daily email newsletters
Access to full search results
Access archive of magazine back copies
Access to Projects in Progress
Access to ONE Research Report of your choice in PDF format

Option 2 (equivalent of R375 a month):

All benefits from Option 1
PLUS
Access to Creamer Media's Research Channel Africa for ALL Research Reports, in PDF format, on various industrial and mining sectors including Electricity; Water; Energy Transition; Hydrogen; Roads, Rail and Ports; Coal; Gold; Platinum; Battery Metals; etc.

Already a subscriber?

Forgotten your password?

MAGAZINE & ONLINE

SUBSCRIBE

RESEARCH CHANNEL AFRICA

SUBSCRIBE

CORPORATE PACKAGES

CLICK FOR A QUOTATION







sq:0.088 0.144s - 178pq - 2rq
Subscribe Now