Durban chemical company had no environmental authorisation to operate plant, report finds

4th October 2021

By: News24Wire

  

Font size: - +

United Phosphorus Limited (UPL) had no environmental authorisation to operate its Cornubia chemical factory, nor did it obtain risk assessment and planning permissions as required by environmental and municipal by-laws, a preliminary report has found.

Forestry, Fisheries and Environment Minister Barbara Creecy released the report on the Durban environmental disaster probe on Sunday.

The UPL factory, which stored various types of chemicals, was targeted during the unrest in July.

Water used by firefighters to douse the flames contained chemicals flowed through nearby communities, seeping into the soil, rivers and polluting a large stretch of the Durban North ecosystem and its beaches.

The contamination resulted in the closure of beaches on the North Coast.

Creecy said the chemical spill and fire caused "the most serious environmental catastrophe in recent times".

"Empirical evidence shows that an entire ecosystem, which includes the oHlanga tributary, the uMhlanga estuary, the beaches and the coastal environment, not only in the vicinity of the UPL, but for several kilometres to the north of the uMhlanga estuary mouth, has been seriously impacted and may take several years to recover from this incident.

"In the days following the fire, the air quality in the immediate facility was also affected."

She added environmental authorisation should have been obtained by UPL from the provincial tourism and environmental affairs department.

"In addition, UPL had not obtained a critical risk assessment or planning permissions from the eThekwini Metropolitan Municipality, in terms of the Occupational Health and Safety Act (OHSA) and the relevant municipal by-laws.

"Had the UPL undertaken this process, it would in all probability have been defined as a major hazard institution considering the significant volumes and nature of the chemicals stored at this particular location.

"These assessments would have determined the emergency readiness of the facility in the face of a disaster such as a fire."

UPL said it was "deeply disappointed" Creecy decided to release the preliminary findings without any prior discussion with it.

It added the report was only sent to it late on Saturday night and it would respond in due course to the allegations of non-compliance.

"UPL does not admit any non-compliance with the law, as alleged in the preliminary report."

It said it was also "evident" little has been said about UPL's efforts at containing and cleaning up lost products, its compliance with its National Environmental Management Act (NEMA) obligations and the NEMA Directives issued "all at considerable cost to UPL and in the most adverse circumstances possible".

UPL added Creecy failed to consider the fires, which led to the pollution, were caused by rioters.

"UPL along with many other businesses were left to fend for themselves in the face of unprecedented and unforeseeable levels of violence and criminality. This central fact seems to be conveniently ignored by Minister Creecy's department."

Creecy said criminal investigations had been initiated by an independent team of investigators from the environmental management inspectorate.

A criminal case has since been opened with the Verulam police.

She added she was not pronouncing on the innocence or guilt of UPL."These findings will be made by a court of law once the NDPP [National Directorate of Public Prosecution] makes a decision to prosecute this matter."

Among the recommendations, the report proposed a compliance profile be identified for the chemical storage and manufacturing sectors to assess the need for a national compliance and/or enforcement programme.

Based on the evaluation of the authorities' response to the incident, it was also recommended to determine the need to establish an interdepartmental rapid emergency response team to deal with a certain category of incidents.

The report recommended looking at the feasibility of creating a mobile command centre which had basic equipment which could be used to assist in the government's response to these types of incidents.

Creecy said clean-up teams were applying various measures to contain the spillage, including the physical removal of sediment from the system.

So far, 13 000 tons of contaminated solids and 23.4 million litres of contaminated liquids have been removed from the UPL site and the environment.

The affected areas remained a "emergency situation," she added.

"Accordingly, I will ensure that the national department continues to provide critical specialist support to the Joint Operational Centre. The national Green Scorpions will also continue to lead the criminal investigation that was initiated and work closely with the other entities involved in this investigation. "The danger has not yet passed. But in time, with enough remedial work and attention, we hope the environment will recover and those responsible for this incident, directly and indirectly, will have to own up and take responsibility for their actions."
 

Edited by News24Wire

Comments

The functionality you are trying to access is only available to subscribers.

If you are already a subscriber, you can Login Here.

If you are not a subscriber, you can subscribe now, by selecting one of the below options.

For more information or assistance, please contact us at subscriptions@creamermedia.co.za.

Option 1 (equivalent of R125 a month):

Receive a weekly copy of Creamer Media's Engineering News & Mining Weekly magazine
(print copy for those in South Africa and e-magazine for those outside of South Africa)
Receive daily email newsletters
Access to full search results
Access archive of magazine back copies
Access to Projects in Progress
Access to ONE Research Report of your choice in PDF format

Option 2 (equivalent of R375 a month):

All benefits from Option 1
PLUS
Access to Creamer Media's Research Channel Africa for ALL Research Reports, in PDF format, on various industrial and mining sectors including Electricity; Water; Energy Transition; Hydrogen; Roads, Rail and Ports; Coal; Gold; Platinum; Battery Metals; etc.

Already a subscriber?

Forgotten your password?

MAGAZINE & ONLINE

SUBSCRIBE

RESEARCH CHANNEL AFRICA

SUBSCRIBE

CORPORATE PACKAGES

CLICK FOR A QUOTATION